Generac-power-systems 004916-0 Manual do Utilizador

Installation andOwner’s ManualAir-cooled, PrepackagedAutomatic Standby GeneratorsModel No. 004916-0(10 kW NG, 11 kW LP)DANGERDEADLY EXHAUST FUMES. OUT

1.10.2 TRANSFER SWITCHThis generator should only be installed with a com-patible transfer switch. A range of transfer switches are offered by the manu

9The following procedures are to be observed:• Wear full eye protection and protective clothing;• Where electrolyte contacts the skin, wash it off

10 DANGER Proceed with caution! Generator power voltage is now supplied to the transfer switch. Contact with live transfer switch parts will result

11With the generator running and loads powered by generator AC output, turn ON the utility power supply to the transfer switch. The following should

12 3.2.2 “OFF” POSITIONThis switch position shuts down the engine. This position also prevents automatic operation.3.2.3 “MANUAL” POSITIONSet the swi

13Section 3 — OperationAir-cooled 11 kW Generators3.5 SETTING THE EXERCISE TIMERThis generator is equipped with an exercise timer. Once it is set,

14 Section 4 — MaintenanceAir-cooled 11 kW Generators3.6.5 LOW BATTERYThe microprocessor will continually monitor the bat-tery voltage and turn on th

15Section 4 — MaintenanceAir-cooled 11 kW Generators  Any attempt to crank or start the engine before it has been properly serviced with the recom

16 Section 4 — MaintenanceAir-cooled 11 kW GeneratorsFigure 4.5 – Setting the Spark Plug Gap4.7 BATTERY MAINTENANCEThe battery should be inspected pe

17• Loosen the rocker jam nut. Use an 10mm allen wrench to turn the pivot ball stud while checking clearance between the rocker arm and the valve st

INTRODUCTIONThank you for purchasing this model of the Quiet Source product line by Generac Power Systems Inc. This model is a compact, high perform

18 7. Remove the spark plug(s) and spray fogging agent into the spark plug(s) threaded openings. Reinstall and tighten the spark plug(s).8. Remove

19Section 4 — MaintenanceAir-cooled 11 kW Generators4.13 SERVICE SCHEDULEATTENTION: It is recommended that all service work be performed by the ne

20 Section 5 — Troubleshooting Air-cooled 11 kW Generators5.1 TROUBLESHOOTING GUIDEProblem Cause CorrectionThe engine will not crank. 1. Fuse bl

AIROUTLETAIR INTAKEREAR VIEWRIGHT SIDE VIEWFRONT VIEWTOP VIEW(WITH ROOF OPEN)(SERVICE DOOR OPEN)"DO NOT LIFT BY THE ROOF"LIFTING HOLES 4-COR

22 Section 7 — Electrical DataAir-cooled 11 kW GeneratorsWiring Diagram – Drawing No. 0E7071-B1466A1619466778685182216214224B21L.E.D - ALARM INDICATO

23Section 7 — Electrical DataAir-cooled 11 kW GeneratorsWiring Diagram – Drawing No. 0E7071-BCLOSEST TO BEARINGGRD 1GRD 2STATO RENGINE WIRING8544SWI

24 Section 7 — Electrical DataAir-cooled 11 kW GeneratorsElectrical Schematic – Drawing No. 0E7073-B225B224B1315561615B562398615BPRINTED CIRCUIT11131

25Section 7 — Electrical DataAir-cooled 11 kW GeneratorsElectrical Schematic – Drawing No. 0E7073-BWINDINGCB3 - CIRCUIT BREAKER, EXTERNAL OUTLET, PU

26 6095736020722115515354697677751748474952505546176731857344744238271826702528232991722"A"15143734"A"411717878630163743176027843

27ITEM PART NO. QTY. DESCRIPTION 1 0E7325 4 HHFS, 1/4"-20 X 5/8" GRADE 5 4 0E6884 1 SEAL, ALTERNATOR SHAFT 5 0E4706A 1 SOUND BAF

Table of ContentsAir-cooled 11 kW Generators 1Introduction ... Inside Front Cover Read This Manual Thoroughly ...

28 2947434252440252533544887484647433871821011,1395060363235395032333961623132265719922631611,125958171615205620222430513132272188720166465652Section

29ITEM PART NO. QTY. DESCRIPTION 1 0E3312 1 ASSEMBLY, HOME STANDBY CONTROLLER 2 0A1801 1 ASSEMBLY, BATTERY CHARGER ENGINE 3 083049 1 ASSE

30 5340353739385441425655505117233313034262827329184255413236444543474916145219156232122129107118Section 8 — Exploded Views and Parts ListsAir-cooled

31ITEM PART NO. QTY. DESCRIPTION 1 0C5730A 1 ASSEMBLY, CRANKCASE RV 2 0E9843 1 SEAL, 38 I.D. CRANKCASE 3 090388 6 SCREW, HHTT M6-1.0 X 1

32 502571911924231819212221911651517114131211832016765584434282726323129393035333857533752"B"4936511925455194043444450444847461019197411009

33Section 8 — Exploded Views and Parts ListsAir-cooled 11 kW GeneratorsEngine Accessories – Drawing No. 0F2001-DITEM PART NO. QTY. DESCRIPTION 1 04

34 26302491231022211128273142414440393851520181415317163332198642343345124384347464853504925373836353Section 8 — Exploded Views and Parts ListsAir-co

35Section 8 — Exploded Views and Parts ListsAir-cooled 11 kW GeneratorsAlternator & Pulleys – Drawing No. 0E4880ITEM PART NO. QTY. DESCRIPTION

36 17920282521241911102322221526141316121882993027453217126151416131921252024121823Section 8 — Exploded Views and Parts ListsAir-cooled 11 kW Generat

37ITEM PART NO. QTY. DESCRIPTION 1 0D5694 1 CASTING, TWIN REGULATOR HOUSING 2 0F5022 1 SOLENOID COIL, 12VDC 3 0C4647 1 GASKET , SOLENOID

2 Study these SAFETY RULES carefully before install-ing, operating or servicing this equipment. Become familiar with this Owner’s Manual and with the

38 Section 9 — NotesAir-cooled 11 kW Generators

39Section 9 — NotesAir-cooled 11 kW Generators

40 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENTYOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air Resources Board (CARB) and Generac Power Syst

41EMISSION CONTROL SYSTEM WARRANTYEmission Control System Warranty (ECS Warranty) for 1995 and later model year engines:(a) Applicability: This war

Part No. 0E4885 Revision E (12/06/05) Printed in U.S.A.Section 10 – WarrantyAir-cooled 11 kW GeneratorsGENERAC POWER SYSTEMS “TWO YEAR” LIMITED WARRAN

3 ELECTRICAL HAZARDS • All generators covered by this manual produce dangerous electrical voltages and can cause fatal electrical shock. Utility p

DANGER Only qualified electricians or contractors should attempt such installations, which must comply strictly with applicable codes, standards and

Section 1 — General InformationAir-cooled 11 kW Generators 51.5 THE GENERATORExhaustEnclosureOil FilterOil DipstickAir FilterBattery CompartmentCon

6 Section 1 — General InformationAir-cooled 11 kW Generators1.6 SPECIFICATIONS1.6.1 GENERATOR Model 04916-0 Rated Max. Continuous Power Capacity (

71.7 FUEL REQUIREMENTS AND RECOMMENDATIONSWith LP gas, use only the vapor withdrawal sys-tem. This type of system uses the vapors formed above the